Seed Home v2 Data Collection - Revision history

Marcin: /* Carport */

2023-03-26T19:16:00Z

Carport

← Older revision		Revision as of 19:16, 26 March 2023
Line 163:		Line 163:
	*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.		*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.

	45.5 so far (about 20 hrs for carport railing posts in this)		45.5 so far (about 20 hrs for carport railing posts in this. Does not include the start of railing posts (half done?) durring the summer with people from under the bridge)

	=Finish Grading and Insulation Skirt + Carport=		=Finish Grading and Insulation Skirt + Carport=

Marcin: /* Carport */

2023-03-26T19:14:38Z

Carport

← Older revision		Revision as of 19:14, 26 March 2023
Line 163:		Line 163:
	*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.		*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.

	45.5 so far (about 20 hrs for posts in this)		45.5 so far (about 20 hrs for carport railing posts in this)

	=Finish Grading and Insulation Skirt + Carport=		=Finish Grading and Insulation Skirt + Carport=

Marcin: /* Carport */

2023-03-26T19:08:21Z

Carport

← Older revision		Revision as of 19:08, 26 March 2023
Line 163:		Line 163:
	*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.		*D7 - 2 people, 3 hours each, rest was 1 hr setup. Panels on carport. Leveling with laser, adding battens. Some battens were twisted. Trimmed EPDM at North side.

	45.5 so far		45.5 so far (about 20 hrs for posts in this)

	=Finish Grading and Insulation Skirt + Carport=		=Finish Grading and Insulation Skirt + Carport=

Marcin: /* Top - Gutter + Top Decorative Band */

2023-03-26T19:02:46Z

Top - Gutter + Top Decorative Band

← Older revision		Revision as of 19:02, 26 March 2023
Line 68:		Line 68:
	*D76 - Fri Ma4 18 - 3.5 hrs - started the canopy. Finished build instructions. Cut everything, ready to mount its ceiling [https://docs.google.com/presentation/d/19gjpeJAgGPyr99-TzGUAw-sdOla8ZovahU4BO_R8f4Y/edit#slide=id.g11d7d3a0aca_4_52]		*D76 - Fri Ma4 18 - 3.5 hrs - started the canopy. Finished build instructions. Cut everything, ready to mount its ceiling [https://docs.google.com/presentation/d/19gjpeJAgGPyr99-TzGUAw-sdOla8ZovahU4BO_R8f4Y/edit#slide=id.g11d7d3a0aca_4_52]

	=Top - Gutter + Top Decorative Band=		=Top - Gutter + Top Decorative Band + top siding=
	*D75 - Thu Mar 17 - 6 hr. Top band - siding done. 8 inch on sides with starter strip, 5" on front and back, loose hang with screw down through slots made with drill in body. Used 3/16 but as a mill in a cordless drill. Trick - mount pieces of siding as spacers to set starter strip location. Deck screws. Then remove marker starter strip and don the real starter strip - it can be put on over deck screws. Top band pinches nailing fin to cover nails - top siding is still nailed. Everything is intended to be loose for thermal expansion.		*D75 - Thu Mar 17 - 6 hr. Top band - siding done. 8 inch on sides with starter strip, 5" on front and back, loose hang with screw down through slots made with drill in body. Used 3/16 but as a mill in a cordless drill. Trick - mount pieces of siding as spacers to set starter strip location. Deck screws. Then remove marker starter strip and don the real starter strip - it can be put on over deck screws. Top band pinches nailing fin to cover nails - top siding is still nailed. Everything is intended to be loose for thermal expansion.
	*D74 Mar 16 5 hr finishing top of house. Did the white band, some of front siding. J-chan on 4 corners. Marked all around for level of nailing fin. Nailed off the 5 and 8 inch bands. Now to finish the siding on 4 sides - 2-4 hours expected.		*D74 Mar 16 5 hr finishing top of house. Did the white band, some of front siding. J-chan on 4 corners. Marked all around for level of nailing fin. Nailed off the 5 and 8 inch bands. Now to finish the siding on 4 sides - 2-4 hours expected.

Marcin: /* Trellis */

2023-03-26T19:02:24Z

Trellis

← Older revision		Revision as of 19:02, 26 March 2023
Line 152:		Line 152:
	*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps. How many frames? 12.		*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps. How many frames? 12.

	41 so far (30/24 for 1300 sf/1000 sf implies 51.25 for trellis)		'''41 so far (30/24 for 1300 sf/1000 sf implies 51.25 for trellis)'''. Note that the top band itself (see above) required as much time as this!''' or 40 more hours. Next time it's expected to take

	=Carport=		=Carport=

Marcin: /* Top - Gutter + Top Decorative Band */

2023-03-26T19:00:58Z

Top - Gutter + Top Decorative Band

← Older revision		Revision as of 19:00, 26 March 2023
Line 86:		Line 86:
	*D59 - 4.75 hr- Gutter work. Sun Feb 20. Leveled gutter with water. Gutter level from trellis level - 1/2" fall on far side, 1.5" fall on near side to downspout. Added backing 1x4. Installed downspout. Joined 2 gutter sections. Capped both. Vise grips do not work to plug end caps. Used a rivet. 2 rivets for mid. 4 rivets for downspout.		*D59 - 4.75 hr- Gutter work. Sun Feb 20. Leveled gutter with water. Gutter level from trellis level - 1/2" fall on far side, 1.5" fall on near side to downspout. Added backing 1x4. Installed downspout. Joined 2 gutter sections. Capped both. Vise grips do not work to plug end caps. Used a rivet. 2 rivets for mid. 4 rivets for downspout.

	Top decorative band total (no gutter) -		'''Top decorative band total only (no gutter or siding) - 39.75 hr. Major nightmare.'''

	=Vinyl Siding=		=Vinyl Siding=

Marcin: /* Top */

2023-03-26T19:00:08Z

Top

Marcin: /* Ceiling */

2023-03-26T18:48:36Z

Ceiling

← Older revision		Revision as of 18:48, 26 March 2023
Line 133:		Line 133:
	46 so far		46 so far

	=Ceiling=		=Interior 2nd floor Ceiling=
	*D21 - 8.5 hr - 12 panels to finish at 3 am. Lessons: last panel - added block (1x10 stake) as underside to nail into. Some panels - need to punch in nails. Where missed the joists - could feel solid vs non-attach - if veered off, redid right there. Edges - nail every 2 inch. Otherwise 6-8" spacing throughout. Single side support works as triangle, single long roof attached 2x4 (6 foot undergrad) works no problem. Buy everywhere - support is not exact as everywhere one hand holds, other nails. 45 min per panel average, including little breaks. Messed up one edge which was too tight - cut with circular saw from underneath with plunge. This was mis-cut (wrong edge was cut so factory edge did not go against last panel. Packed insulation into some gaps. Unruly insulation makes it hard to press up when sliding panel in over support. Some edges very tight - used a board to hammer panel in. Some have 1/8" gap - will expansion be an issue? Could see ceiling suck in if already nailed and put in extra nails to even out edges. Overall - blocking works well, surface relatively decent.		*D21 - 8.5 hr - 12 panels to finish at 3 am. Lessons: last panel - added block (1x10 stake) as underside to nail into. Some panels - need to punch in nails. Where missed the joists - could feel solid vs non-attach - if veered off, redid right there. Edges - nail every 2 inch. Otherwise 6-8" spacing throughout. Single side support works as triangle, single long roof attached 2x4 (6 foot undergrad) works no problem. Buy everywhere - support is not exact as everywhere one hand holds, other nails. 45 min per panel average, including little breaks. Messed up one edge which was too tight - cut with circular saw from underneath with plunge. This was mis-cut (wrong edge was cut so factory edge did not go against last panel. Packed insulation into some gaps. Unruly insulation makes it hard to press up when sliding panel in over support. Some edges very tight - used a board to hammer panel in. Some have 1/8" gap - will expansion be an issue? Could see ceiling suck in if already nailed and put in extra nails to even out edges. Overall - blocking works well, surface relatively decent.
	*D21 - 8 hrs, first 4 panels with learning curve. Cleanup initially - about an hour or two- see video tape for detail. Side triangles work well. Tall stand does not. Holders from 2 sides work - mid point support. Unsymmetrical support - too much strain on corner. Broke one panel edge this way. 4 mid-blockings work. 5+3 2" finish nails for blocking. On edge - nails every 6". Started with screws - takes too much time. Nails can break through panel - slight angle helps. Started in middle row, above the stairs. Start away from stairs - all the setup there takes too long. Last row is cut as in plan. Blocking is pre-attached. Last row is ted - quick. Summary: triangle support - _single one_ - is sufficient. 2 mid supports from side work best.		*D21 - 8 hrs, first 4 panels of ceiling with learning curve. Cleanup initially - about an hour or two- see video tape for detail. Side triangles work well. Tall stand does not. Holders from 2 sides work - mid point support. Unsymmetrical support - too much strain on corner. Broke one panel edge this way. 4 mid-blockings work. 5+3 2" finish nails for blocking. On edge - nails every 6". Started with screws - takes too much time. Nails can break through panel - slight angle helps. Started in middle row, above the stairs. Start away from stairs - all the setup there takes too long. Last row is cut as in plan. Blocking is pre-attached. Last row is ted - quick. Summary: triangle support - _single one_ - is sufficient. 2 mid supports from side work best.
	*D20 - 4 hrs. Site cleanup, moving materials. Covering for snow. Moved materials for doing vinyl siding. Prepped for vinyl siding all week including trim. Winterized Bosch heater in Faculty house and other final winterization (not counted in hours).		*D20 - 4 hrs. Site cleanup, moving materials. Covering for snow. Moved materials for doing vinyl siding. Prepped for vinyl siding all week including trim. Winterized Bosch heater in Faculty house and other final winterization (not counted in hours).
	*D19 - 2hrs. Painting, site prep for siding. Cleanup. Messing with nail guns.		*D19 - 2hrs. Painting, site prep for siding. Cleanup. Messing with nail guns.

Marcin: /* Trellis */

2023-03-26T18:47:00Z

Trellis

← Older revision		Revision as of 18:47, 26 March 2023
Line 144:		Line 144:
	=Trellis=		=Trellis=
	*[[Trellis Procedure Notes]]		*[[Trellis Procedure Notes]]
	*D17 - Tue - 6 MJ + 6 KM. Trellis white band corner pieces - 4 extensions. Trellis - second band + stain wood. Cut verticals for second band. Moved treated lumber to site. Took down trellis supports. See the video tape for hour verification..		*D17 - Tue - 6 MJ + 6 KM. Trellis white band corner pieces - 4 extensions. Trellis - second band of main trellis (not top extension) + stain wood. Cut verticals for second band. Moved treated lumber to site. Took down trellis supports. See the video tape for hour verification..
	*D16 - Mon - 4 hrs total. Hanging trellis and white band, hung 4 white bands and 9 trellis pieces by now.		*D16 - Mon - 4 hrs total. Hanging trellis and white band, hung 4 white bands and 9 trellis pieces by now.
	*D15 - 4 hr total - Sunday - Too cold. First white band piece. Second white band (first band on west side). Trellis lag bolts.		*D15 - 4 hr total - Sunday - Too cold. First white band piece. Second white band (first band on west side). Trellis lag bolts.
Line 150:		Line 150:
	*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps. How many frames? 12.		*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps. How many frames? 12.

	41 so far		41 so far (30/24 for 1300 sf/1000 sf implies 51.25 for trellis)

	=Carport=		=Carport=

Marcin: /* Trellis */

2023-03-26T18:44:39Z

Trellis

← Older revision		Revision as of 18:44, 26 March 2023
Line 148:		Line 148:
	*D15 - 4 hr total - Sunday - Too cold. First white band piece. Second white band (first band on west side). Trellis lag bolts.		*D15 - 4 hr total - Sunday - Too cold. First white band piece. Second white band (first band on west side). Trellis lag bolts.
	*D14 - 8 hr total. Laid up first to fifth trellis. Built triangle supports and hung them to mount trellises. Moved trellises to roof. Predrilling trellises for bolts and screws. 8 hours?		*D14 - 8 hr total. Laid up first to fifth trellis. Built triangle supports and hung them to mount trellises. Moved trellises to roof. Predrilling trellises for bolts and screws. 8 hours?
	*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps.		*D13 - MJ 6 hrs, KM 7 hrs - Began Trellis Frames - 2x6. Got wood over to house. Finished all frames, into dark with headlamps. How many frames? 12.

	41 so far		41 so far