Gas Storage in PVC Pipe

6" Pipe for Methane

Have you considered PVC pipe for gas storage? 6" costs $45 for a 20' section, caps are $15 (verify). Pipe + 2 caps is $75.

Each 20' section holds about 4 cubic feet of gas. So $750 gets us 40 cubic feet, or about 300 gallons equivalent. So comparable to new propane gas tanks.

At 10 atmospheres (note this PVC is rated only for 100 PSI, not 140), that is equivalent to 3000 gallons of gas at one atmosphere. About 600 moles of gas, if primarily methane then it is about 10 kg of methane, or about 3.5 gallons of gasoline equivalent. [1]

That is 14 kWhrs of electricity from a Honda EU1000 generator.

Comparison to 1" Pipe for Hydrogen

Medium pressure production of hydrogen occurs at 33ATM, without need for pumping.

• If 6" pipe is $75 for 4 cubic feet - what is the price comparison for 1" pipe?
• It is .785 cu in per inch of pipe, or 188 cu in per stick. of 1728 cu in per cu ft - 1/10 cu ft per pipe. 40 cubic feet would be 400 pipes.
• At $5 per stick and $0.59 per cap, this is $2.5k for this storage. Couplings are 28 cents, so cost may be slightly lower.
• What about hydrogen? For 600 moles, that is 1.2 kg of hydrogen. With the specific energy density of gasoline 1/3 that of hydrogen - that is about 4 kg of gasoline, or 1.4 gallons of gasoline. That is more than enough for storage over night.

• Note: Honda EU1000 burns 1 quart per hour to generate 1kWhr. Using such an efficient generator for electricity, we get about 5kWhr from the stored hydrogen.
• This makes for approximately $500/kWhr storage cost

This implies that if we could split water, we could store it effectively from a very small area of solar collection - if PV is 10% efficient, and biomass production is .1%, there is about a 100x efficiency increase in using PV for fuel storage compared to biomass.

Comparison to Batteries

The methane or hydrogen storage route are both comparable in cost for pressurized storage. Hydrogen is more energy efficient in terms of solar capture area compared to biomass-derived methane, by about 100x. Advantage of hydrogen is not needing a pressure pump. If the pressure vessel cost is $2.5k, that is a worthwhile investment for going off grid.

Note that PVC pipe lifetime is 100+ years. This qualifies for OSE's metric of lifetime design. This is also about 20 times cheaper than lead acid batteries, based on a 10 yr life of deep cycle batteries.

Battery Cost

• Deep cycle batteries are $200-300/kWhr [2]

• Let's see on ebay - $125 for about a 1kWhr Trojan (close to 200A at 6V).
• Trojan T-1275 150AH [3] - $190 on Ebay [4]. 1.3kWhr at 80% DoD at 10 hour rate. 150A rating is at the 20 hour rate.

• To store 1 kWhr thus costs at least

See Also

• Open Source Fuels Construction Set

• PVC Pipe Pressure Rating

• Energy Density of Fuels

Usefull Links

• A youtube video with a good unseperated water electrolyser If we made a design with two of these connected to form a U shape or a H shape it could produce seperate hydrogen and oxygen streams which are more stable.