Freezer to Refrigerator Conversion: Difference between revisions

From Open Source Ecology
Jump to navigation Jump to search
(Undo revision 169210 by Dorkmo (talk))
Line 46: Line 46:
*[https://www.sparkfun.com/products/13244 USB Micro Cable] $1.95
*[https://www.sparkfun.com/products/13244 USB Micro Cable] $1.95
*[http://www.homedepot.com/p/4-in-x-4-in-x-2-in-PVC-Junction-Box-E989NNJ-CAR/100404097 Junction Box] $7.23
*[http://www.homedepot.com/p/4-in-x-4-in-x-2-in-PVC-Junction-Box-E989NNJ-CAR/100404097 Junction Box] $7.23
*Twin-screw cable clamp [http://www.homedepot.com/p/3-8-in-Non-Metallic-NM-Twin-Screw-Cable-Clamp-Connectors-5-Pack-20511/100133208 HomeDepot]
*Extension Cord - Ace Hardware
*Extension Cord - Ace Hardware
*2 Conductor Speaker Wire - Ace Hardware
*2 Conductor Speaker Wire - Ace Hardware

Revision as of 02:48, 5 April 2018

Introduction

Convert a freezer to a refrigerator, and reduce energy consumption 12x so that your refrigerator uses 8 Watts of average power.

This translates to about 50 million megawatt hours of electricity (126M households with 1 fridge) saved per year in the USA if everyone converted to an energy saving fridge from a 1kWhr/day scenario today. This is about $5 billion dollars saved per year in America.

Nearly every household on Earth has a verticaldoor fridge that uses 100W of power on average - or about 2.4 kWh per day. In a country of a few million households, replacing vertical door refrigerators with chestfridges can save enough energy to allow closing down at least one large power station. Alternatively, construction of a new power station to meet the increasing energy demand could be avoided or delayed. http://mtbest.net/chest_fridge.html

In money terms, the Superfridge costs 2 cents per day to run (assuming 10 vent per kWh electricity cost). This is about $7 per year - compared to $88 for an average fridge.

For the Seed Eco-Home, the cost is actually even better. The off-grid energy system cost $3000 for 3kW not including labor. This translates to 2 cents per kWh energy cost over a 20 year life of the PV system. That is about $1.50 electricity cost to run the refrigerator for a whole year!

Original Work

This work is based on the Mt_Best_Freezer_to_Refrigerator_Conversion.

edit

Wiring Diagram

OSE Fridge Conversion Wiring.png

google doc

Wiring Harness

OSE - Fridge Conversion v0318 - Wiring Harness.png

google doc

BOM

sparkfun

amazon

Arduino Code

//A1 read voltage
//D3 sensor power
//D14 relay (-)


  volatile int sensorvalue = 328; //define the variable
  int triggeron = 328;         //number that will trigger fridge on
  int triggeroff = 304;        //number that will trigger fridge off


// the setup function only runs once every time the chip is reset
void setup() {
  digitalWrite(3, HIGH); //for powering thermister  
  digitalWrite(14, HIGH);  //for switching relay
  pinMode(3, OUTPUT);    //begin operating pin
  pinMode(14, OUTPUT);    //begin operating pin
  delay(20000);          // wait for thermister to get a good initial reading
}

// the loop function runs over and over again forever
void loop() {
  sensorvalue = analogRead(A1);   //read sensor
if (sensorvalue > triggeron){     //if sensor reads over triggeron, turn on
  digitalWrite(14, LOW);       //turn on relay
  delay(8000);                 //wait 8 seconds
}
if (triggeroff > sensorvalue){   //if sensor reads below triggeroff, turn off
  digitalWrite(14, HIGH);         //turn off relay
  delay(8000);                  //wait 8 seconds
}
}

Other Options

Further Reading

Retrieved from "https://wiki.opensourceecology.org/index.php?title=Freezer_to_Refrigerator_Conversion&oldid=169337"